partial replacement of fine aggregate in concrete

2020-12-15T05:12:53+00:00
  • Concrete using agro-waste as fine aggregate for ...

    12/1/2016  Thus other agro-wastes could be used as partial replacement of fine aggregate in self-compacting concrete and observed their effect on properties of SCC. 5. Further research work is required regarding these agro-wastes as a fine aggregate replacement in concrete to confirm the strength variation and thermal property. 10. Conclusion

  • Cited by: 59
  • Partial Replacement of Fine Aggregate in Concrete by Tyre ...

    3/4/2020  One of the solutions suggested was the use of tyre rubber as partial replacement of fine aggregate in cement-based materials. An experimental program was carried out to investigate the compressive strength of concrete with shredded tyres as a fine aggregate in concrete .A number of cubes, prisms, cylinders were casted of M25 grade for this study.

  • Author: Jasmin M, Hafiz Hashimkutty
  • (PDF) REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

    In Group 3, wood waste aggregate has been used as a partial replacement of 10%, 15%, 20%, 25% and 30% by volume of coarse aggregate. The specimens were conditioned for 28-days at

  • partial replacement of fine aggregate by glass powder in ...

    4/5/2015  The partial replacement of glass powder as fine aggregate Makes the concrete strengthen. Thus our project states that concrete can be strengthen by glass powder replacement , which makes the waste in to useful, so the waste materials made in to use. 40.

  • REPLACEMENT OF FINE AGGREGATE WITH JAROFIX IN CONCRETE

    for the replacement of fine aggregate in concrete. Aggarwal et al [3] observed that the bottom ash can be replaced as fine aggregate upto 50% without affecting the properties of concrete. Siva et al. [25] had done experimental investigation on partial replacement of fine aggregate

  • Replacement of Fine Aggregate with Bottom Ash in Concrete ...

    The results proved that the replacement of 100% of fine aggregate by bottom-ash achieved higher compressive strength. Thus the environmental effects due to illegal extraction of sand and cost of conventional fine aggregate can be significantly reduced. Key Words: bottom ash, fine aggregate, replacement, concrete. INTRODUCTION

  • Partial Replacement Of Fine Aggregate Using Steel Slag

    steel slag as partial replacement of fine aggregate. For this purpose different test on harden concrete were conducted at the age of 28 days like compressive strength on 150 x 150 x 150 mm size cube, splitting tensile strength on 150 mm X 300 mm cylinder,

  • Utilization of Steel Slag in Concrete as a partial ...

    Utilization of steel slag in concrete as a partial replacement material for fine aggregates was studied by Kothai et al. [10], and found that fine aggregate replacement shows better workability ...

  • Partial Replacement of Coarse Aggregate with Demolished ...

    investigations carried out to evaluate the effect of partial replacement of cement, fine aggregate and coarse aggregate by different parts of demolished wastes on strength and workability of concrete made. For the study, design mix concrete of grade M25 (Referral concrete) was prepared using IS

  • Utilization of Bagasse Ash as a Partial Replacement of ...

    1/1/2013  The present study was carried to study the use of SCBA as a partial replacement of fine aggregate in cement concrete since the availability of natural sand is on the cry off in the last decades as a result of ecological and environmental limitations.

  • PARTIAL REPLACEMENT OF PARTIAL REPLACEMENT OF FINE ...

    b) Fine aggregate (not greater than 4.75mm) c) Coarse aggregate (20mm size) d) Crumb rubber (0.6mm size for 20%, 30% of replacement) III OBJECTIVES OF REPLACEMENT x To investigate the structural behaviour of such replaced concrete components x As partial substitute for the fine aggregate (sand) in concrete composites

  • Partial Replacement of Steel Slag Aggregates in Concrete ...

    It is found that the strength results of 0 M 0 and 0 M 50 are comparable indicating the suitability of using slag aggregate as an alternative for river sand. However, the third mix with fly ash replacement in binder showed reduced strength in comparison with control concrete. Hence, it is concluded that when slag aggregate is used as a partial ...

  • STUDY ON PARTIAL REPLACEMENT OF PLASTIC WASTE AS FINE ...

    STUDY ON PARTIAL REPLACEMENT OF PLASTIC WASTE AS FINE AGGREGATE IN CONCRETE Elango A1, Ashok Kumar A2 1,2Assistant Professor, 1TKR College of Engineering Technology (K9), 2TKR Engineering College (R9),Hyderabad, Telangana State. ABSTRACT Disposal of used Plastics is a major problem in the present era, as the usage of plastics is

  • Partial Replacement of Fine Aggregate Coarse Aggregate ...

    Keywords: Concrete, waste glass powder, coconut shell, partial replacement, fine aggregate, coarse aggregate, drying shrinkage, compressive strength, workability test such slump cone test 1. INTRODUCTION Concrete is the second largest of widely used material; but there are environmental issues related with its use which are

  • UTILIZATION OF PLASTIC WASTE IN CONCRETE AS A PARTIAL ...

    UTILIZATION OF PLASTIC WASTE IN CONCRETE AS A PARTIAL REPLACEMENT OF FINE AGGREGATE S. Das1*, M. T. Alam2 I. Chowdhury2 1 Institute of Earthquake Engineering Research, Chittagong University of Engineering and Technology, Chittagong, Bangladesh 2 Department of Civil Engineering, Chittagong University of Engineering and Technology, Chittagong, ...

  • PARTIAL REPLACEMENT OF FINE AGGREGATE AND CEMENT IN ...

    PARTIAL REPLACEMENT OF FINE AGGREGATE AND CEMENT IN CONCRETE PAVEMENT BY PHOSPHOGYPSUM Brijesh Kumar Gour1, Mukesh Choudhary2, Dr. Bharat Nagar3 1M. Tech. Scholar, Department of Civil Engineering, Jagannath University, Jaipur, Rajasthan, India 2Assistasnt Professor, Department of Civil Engineering, Jagannath University, Jaipur, Rajasthan, India

  • Partial Replacement of Fine Aggregate Cement in Concrete ...

    Partial Replacement of Fine Aggregate Cement in Concrete with Ceramic Rejects Sadic Azeez1 2, Remya Raju , Dr. P.R Sreemahadevan Pillai3 1M Tech student, Civil Department, Ilahia College of Engineering Technology,Kerala , India 2Professor, Civil Department, Ilahia College of Engineering Technology,Kerala , India

  • Partial replacement of waste foundry sand and recycled ...

    Partial replacement of waste foundry sand and recycled aggregate in concrete Sarita Chandrakanth1 and Asst.Prof. Ajay.A.Hamane2 1,2 Dept. of Civil Engineering, M.S. Bidwe Engg.College Abstract- Low cost concrete production by replacement of fine sand with Foundry sand is a new

  • The Use of Ceramic Tile Waste as Aggregate in Concrete

    from construction and demolition wastes, in concrete mixes as partial replacement of coarse aggregate with replacement ratios of 0, 1/3, 2/3, and 3/3. It was found that as replacement per-centages increases, compressive strength, flexural strength, and loss of thickness by abrasion decreased compared to conven-tional concrete.

  • An Experimental Study on Concrete by using E- Waste as ...

    0% to 30% electronic waste as partial replacement to coarse aggregate along with this 10% to 30%fly ash as a partial replacement of fine aggregate. Once design of mix has been prepared then 150*150*150mm cubes is casted for these mixes, 9

  • Walnut Shell for Partial Replacement of Fine Aggregate in ...

    7/4/2017  that using sawdust as partial replacement of fine aggregate up to 25% will contributes to reduction in sawdust waste generation without adversely affecting concrete strength [30]. Close relations were predicted by using groundnut shells for partial replacement of fine aggregate in concrete [27].

  • Partial Replacement of Fine Aggregate Cement in Concrete ...

    Partial Replacement of Fine Aggregate Cement in Concrete with Ceramic Rejects Sadic Azeez1 2, Remya Raju , Dr. P.R Sreemahadevan Pillai3 1M Tech student, Civil Department, Ilahia College of Engineering Technology,Kerala , India 2Professor, Civil Department, Ilahia College of Engineering Technology,Kerala , India

  • PARTIAL REPLACEMENT OF FINE AGGREGATE AND CEMENT IN ...

    PARTIAL REPLACEMENT OF FINE AGGREGATE AND CEMENT IN CONCRETE PAVEMENT BY PHOSPHOGYPSUM Brijesh Kumar Gour1, Mukesh Choudhary2, Dr. Bharat Nagar3 1M. Tech. Scholar, Department of Civil Engineering, Jagannath University, Jaipur, Rajasthan, India 2Assistasnt Professor, Department of Civil Engineering, Jagannath University, Jaipur, Rajasthan, India

  • Recycling of waste glass as a partial replacement for fine ...

    The properties of concretes containing waste glass as fine aggregate were investigated in this study. The strength properties and ASR expansion were analyzed in terms of waste glass content. An overall quantity of 80 kg of crushed waste glass was used as a partial replacement for sand at 10%, 15%, and 20% with 900 kg of concrete mixes.

  • Utilization of Recycled Glass Waste as Partial Replacement ...

    The properties of concretes containing glass dust waste as fine aggregate were investigated in this study. Glass dust waste was used as a partial replacement for sand at 10%, 20% and 50% of concrete mixes. Compression strength for 7, 14 and 28 days concrete of age were compared with those of concrete made with natural fine aggregates.

  • Sea shells used as partial aggregate replacement in concrete

    11/4/2013  A paired comparison test was carried out examining two different partial replacement shell aggregate mixes against a plain concrete control sample. , – The results showed a reduction in compressive strength when 50 per cent of sea shells were used as an aggregate replacement, for both sand and gravel, compared to the control sample.

  • Experimental Analysis on Partial Replacement of Fine ...

    Upadhyaya S., Nanda B., Panigrahi R. (2019) Experimental Analysis on Partial Replacement of Fine Aggregate by Granite Dust in Concrete. In: Das B., Neithalath N. (eds) Sustainable Construction and Building Materials.

  • PARTIAL REPLACEMENT OF FINE AGGREGATE BY WASTE TYRE

    The percentage replacement of natural fine aggregate with crumb rubber was 5%, 10% and 15%. Key words: Crumb Rubber, Mechanical Properties, Fine Aggregates, Waste Tyre. Cite this Article: Rohit Sharma and Shalika Mehta, Partial Replacement of Fine Aggregate by Waste Tyre Crumb Rubber In Concrete, International Journal of Civil

  • Copper slag as fine aggregate for high performance concrete

    that blast furnace slag aggregate, in combination with other supplementary cementitious materials, could be utilised in making high strength concretes. 2 Research objectives The main objective of this study was to investigate the use of copper slag as partial and/or full replacement for fine aggregate in normal and high strength concrete mixtures.

  • What are the materials that can be replaced as fine ...

    Replace fine aggregates or natural sand ? As if you replace fine aggregates from concrete it will become “No fines Concrete “ used for specific purposes to prepare pervious media. If you want to replace natural sand on the other hand there are ple...

  • PERFORMANCE OF CONCRETE WITH PARTIAL REPLACEMENT OF FINE ...

    comparable to fine aggregate size. 2.2.2 Concrete Mixture The mix ratio used for the experiment was 1:2:4 (cement: fine aggregate: coarse aggregate) by weight, the water/cement ratio was 0.6. The fine aggregate was replaced with WG at 15%, 25%, 35%, 45% and 50% partial replacement for sand. For each replacement level,

  • Partial Replacement of Fine Aggregates (Sand) in concrete ...

    The project covers the employment of recycled e waste plastic aggregate as partial replacement of natural fine aggregate in cement concrete combine. The percentages of recycled plastic fine ...

  • A DETAILED STUDY ON PARTIAL REPLACEMENT OF FINE AGGREGATE ...

    Concrete is the most material being used in infrastructure development throughout the world. Fine aggregate is a prime material used for preparation of mortar and concrete and which plays a major role in mix design. Fine aggregates are weathered and

  • Experimental Study on Partial Replacement of Fine ...

    This paper deals with replacement of sand used in concrete as fine aggregates by the waste generated by the stone quarry industry and red soil. This study has made an attempt to partially replace quarry dust + red soil in place of sand in M20 grade concrete. On experimentation, it was found that the partial replacement of sand with 20%, 30%,

  • partial replacement of fine aggregate by glass powder in ...

    The partial replacement of glass powder as fine aggregate Makes the concrete strengthen. Thus our project states that concrete can be strengthen by glass powder replacement , which makes the waste in to useful, so the waste materials made in to use. 40.

  • Partial Replacement of Copper Slag as Fine Aggregate

    concrete strength compare with control concrete. The graphical representation shows the flexural strength of copper slag. Fig.7. Comparison of Flexural Strength of Beam IV. CONCLUSION The concrete was prepared for the M 25 grade concrete with partial replacement of fine aggregate by copper slag with various percentages of 0%, 10%, 15% and 20%.

  • EXPERMENAL STUDIES ON M20 GRADE CONCRETE BY PARTIAL ...

    aggregate. 3.2 Details of concrete mix: Mix of M 20 grade concrete was designed as per Indian Standard 10262: 2009 and the specimens were cast. During the present study, the fine aggregate was replaced with granite powder and the percentages of granite powder added were 0, 10, 20, 30, 40 and 50% of fine aggregate. 3.3 Mixing of concrete:

  • PARTIAL REPLACEMENTS OF FINE AGGREGATE WITH

    (2012) in a research on the studies of partial replacement of fine aggregate with waste material from China clay industries also concluded that the waste material from china clay industries can be used as a replacement for fine aggregate. It is found that 30% replacement of fine aggregate

  • STEEL SLAG AS REPLACEMENT OF FINE AGGREGATE IN TERMS

    The coarse aggregate chosen for Concrete was typically angular in shape, well graded, and smaller than maximum size suited for conventional concrete. ... Experimental Study on Partial Replacement of Fine Aggregate by Steel Slag. International Journal of Innovative Research in Science, Engineering and Technology. (2014),

  • Sea shells used as partial aggregate replacement in concrete

    11/4/2013  A paired comparison test was carried out examining two different partial replacement shell aggregate mixes against a plain concrete control sample. , – The results showed a reduction in compressive strength when 50 per cent of sea shells were used as an aggregate replacement, for both sand and gravel, compared to the control sample.

  • Any of your enquiry will be highly appreciated.

    Enquiry Now